News & BLOG

Project #Super71 - Right Rear 1/4 Panel

As this project continues to march forward we find ourselves moving to the right rear quarter panel of the 1971 Super Beetle.

The rear quarter panel on this Bug was a mess. The old heater channels were removed by hand and the metal that was supposed to be connecting the body to the channels were extremely thin and repaired a few times over the last 25 years. You could see that a rust hole at the bottom of the door jam and it wasn't going to fix itself. My best description for this VW and especially this area was "Mushy". There was nothing solid, so we were going to have to cut away any rusty or thin metal in order to get to something solid.

VW Beetle Rear Quarter Panel Repair

Just a quick recap... before we tackled the connection of the pre-fabricated heater channel assembly on the Bug, we had to use some ratchet straps to pull everything up into place giving us a perfect 2" gap from the bottom of the door to the bottom lip of the heater channel. We left the door in place and relied on our internal braces to help ensure all of our measurements and gaps would be as they were before we removed the old heater channels from the body.

VW Beetle Rear Quarter Panel Repair - Rotten

VW Beetle Rear Quarter Panel Repair - RUST

The majority of the bad metal was removed earlier in the project with an air chisel. It made quick work of the initial job, but it's not the most accurate tool so our first order of business was to cut a clean line in the body. I worked with the inside section first. I cleaned up the metal and then measured and fabricated my on replacement pieces. Everything was carefully moved into position and welded in place. With this section of the car connected securely to the heat channels it was time too move on to the outside skin.

VW Beetle Rear Quarter Panel Repair

VW Beetle Rear Quarter Panel Repair

VW Beetle Rear Quarter Panel Repair

VW Beetle Rear Quarter Panel Repair

VW Beetle Rear Quarter Panel Repair

Once again I have to clean up and trim the outside sheet metal. I like to do this by using some green masking tape to define a clear cut line, and then use my cut off wheel and saw to carefully trim the metal to perfection. This was required on both the outside skin, and the metal on the inside under the rear seat. At this point we opened up the door so we could properly trim the outside skin all the way into the door jam. I removed as little of the original body metal as possible and instead trimmed and modified the replacement panel to fit the Beetle body. With everything measured twice and cut once I then used my crimping tool to add a small shoulder to the replacement panel so I could puddle weld everything flush.

Once everything was fitting just right I started welding everything in place until the rear quarter panel was looking good and solid. I closed up the door to ensure everything was still properly aligned so I could safely move on to the lower door post. Like every main repair on this Bug, I will do a once over when everything is more or less completed.

VW Beetle Rear Quarter Panel Repair

VW Beetle Rear Quarter Panel Repair

VW Beetle Rear Quarter Panel Repair

Thanks for following the build. Please leave your feedback, questions and comments below.

THEBUGNUT

blog comments powered by Disqus
News & Blog

Project #Super71 - One Rusty Frame Head
This particular VW Beetle came into my life back in 1996 when my mechanic decided we needed a promotional car to take to the local VW shows ...
Project #Super71 - Floor Pans & Tunnel 1.0
After working on some small jobs, it was time to move on to something a little more complicated. In fact, I wasn't even sure how this part ...
Project #Super71 - Goodbye Gas Heater Hole
This is a pretty short entry. I figured it was a good time to fill in the hole in the front wheel well where the exhaust from the factory ...


Get your 3-Pack of 4"x6" die-cut vinyl stickers for only $6.00. We will ship anywhere in Canada or USA for FREE!


My Image

WE WANT TO HEAR FROM YOU

We would love to hear from you. We want to know your VW stories, see pictures, and we are always looking for help with the website and managing the content. Sound interesting? Contact us today for a chat.

Contact Us

Mailing List

Join the club and stay up to dat with all things related to thebugnut.com!

Social Network

Follow us online for live updates.

icon_twitter icon_facebook icon_youtube icon_instagram

VW Logo

All images & content copyright © thebugnut.com 2023

copyright © thebugnut.com 2023

Website Design by Peter Rood

Website Design by Peter Rood